West Milford, NJ, USA
N4153R
PIPER PA32
The private pilot told a friend that he was having problems with his airplane's engine and stated that he was going to taxi to the end of the runway and perform an engine run-up. If the engine run-up was successful, the pilot was going to conduct a short cross-country flight and return. During takeoff, the engine experienced a total loss of power; the airplane subsequently impacted a wooded area about 1,100 ft south of the departure runway. Examination of the wreckage revealed that the airplane experienced an in-flight fire, with the heaviest concentration of thermal damage on the aft right side of the engine compartment. The fuel inlet line from the fuel pump to the fuel servo was loose. According to the manufacturer, the part number of the inlet line installed on the accident airplane was not approved for aircraft use; however, aside from the part number, the approved hose looked identical to the unapproved hose, and the error likely could not be detected during an annual inspection. The airplane's maintenance logbooks were destroyed during the accident and the pilot performed some of the maintenance of the airplane himself; therefore, when and by whom the unapproved hose was installed could not be determined. It is likely that the loose fuel line allowed fuel to spray onto the exhaust system, which resulted in the in-flight fire and the total loss of engine power.
HISTORY OF FLIGHTOn May 2, 2018, about 1410 eastern daylight time, a Piper PA-32-300, N4153R, was destroyed when it impacted terrain after takeoff from Greenwood Lake Airport (4N1), West Milford, New Jersey. The private pilot was fatally injured. The airplane was registered to IHAF Flying Mission LLC and was being operated by the pilot as a Title 14 Code of Federal Regulations Part 91 personal flight. Visual meteorological conditions prevailed, and no flight plan was filed for the flight, which was destined for Orange County Airport (MGJ), Montgomery, New York. A flight instructor at 4N1, who was also a friend of the pilot, stated that he talked with the pilot just before the accident. The pilot told him that he was having problems with the airplane's engine and thought the problem was either the magnetos or the spark plugs. The pilot stated that he was going to taxi to the end of the runway and perform an engine run-up. If the engine run-up was successful, he was going to take a short flight to MGJ and return. A witness located 1 mile north of the airport heard the airplane take off, heard the airplane's engine sputter, then heard a loss of power. He then heard the sound of a crash and called 911. PERSONNEL INFORMATIONThe pilot held a private pilot certificate with a rating for airplane single-engine land. He held a Federal Aviation Administration (FAA) third-class medical certificate, issued April 27, 2016. At the time of the medical examination, the pilot reported 625 total hours of flight experience. The pilot's logbook was onboard the airplane and was consumed by fire. AIRCRAFT INFORMATIONThe six-seat, low-wing, tricycle-gear-airplane was manufactured in 1968. It was powered by a Lycoming IO-540-K1A5, 300-horsepower engine equipped with a two-bladed Hartzell propeller. Family members stated that the maintenance logbooks were carried on the airplane in the luggage compartment. The luggage compartment was consumed by fire and all documents were destroyed. A local mechanic stated that he performed the most recent annual inspection on the airplane in late June 2017. He also stated that the pilot often performed maintenance on his own airplane. METEOROLOGICAL INFORMATIONThe 1353 recorded weather at Sussex Airport (FWN), Sussex, New Jersey, located 13 miles northwest of the accident site, included wind from 220° at 10 knots gusting to 21 knots, 10 statute miles visibility, clear sky, temperature 30°C, dew point 6°C, and an altimeter setting of 30.02 inches of mercury. AIRPORT INFORMATIONThe six-seat, low-wing, tricycle-gear-airplane was manufactured in 1968. It was powered by a Lycoming IO-540-K1A5, 300-horsepower engine equipped with a two-bladed Hartzell propeller. Family members stated that the maintenance logbooks were carried on the airplane in the luggage compartment. The luggage compartment was consumed by fire and all documents were destroyed. A local mechanic stated that he performed the most recent annual inspection on the airplane in late June 2017. He also stated that the pilot often performed maintenance on his own airplane. WRECKAGE AND IMPACT INFORMATIONThe wreckage was located in a wooded area about 1,100 ft south of the departure end of runway 24 and was consumed by a fire. Tree branches were observed broken descending about a 12° angle and extending about 50 ft on a magnetic heading of 110° to the main wreckage. The main wreckage came to rest upright. The instrument panel was consumed by fire. Both wings separated from the fuselage and were located about 30 ft behind the fuselage. The wings exhibited minor fire damage. Fuel was found in both wing tanks and was consistent in color and odor with 100LL aviation fuel. All major components of the airplane were accounted for at the scene. Control cable continuity was confirmed from the cockpit to the flight controls through breaks consistent with overload separations. The engine remained attached to the airframe. The accessories on the right rear of the engine were consumed by fire. The upper right corner of the firewall exhibited a burn area free of soot. The fire sleeving of the oil lines, engine baffling, and oil cooler all exhibited thermal damage. The upper engine cowling was intact but exhibited heavy thermal damage on the aft right side. The lower cowl was heavily sooted and the fiberglass resin was charred and missing in areas. The thermal damage was consistent with an in-flight fire. (For further information, see the Materials Laboratory Fire Factual Report in the NTSB public docket for this accident.) The propeller blades were both bent aft at mid-blade. Thumb compression was established on all cylinders and a lighted boroscope was used to examine all pistons and valves with no anomalies noted. During the engine examination, the inlet fuel line from the fuel pump to the fuel servo was found loose. The line could be moved over 1/8 inch inside the B-nut. Parker Aerospace, the manufacturer of the hose, stated that, based on the hose's part number, it was not approved for airplane use and was intended for industrial use only. The hose looked identical to an approved one, but with a different part number. The fuel servo and the hose that was installed on the airplane were sent to Avstar Fuel Systems, Inc., for operational testing and examination. The test revealed that the servo met all the requirements for flow. The B-nut was loosened during the flow test to simulate the loose line and fuel sprayed from the B-nut immediately after loosening the nut. The B-nut was not loosened to the same amount found during the postaccident examination since fuel was spraying immediately after torque was removed. The fuel pump was sent to CJ Aviation for operational testing and examination. The fuel pump was installed on a test bench and flow tested. The test did not reveal any anomalies. MEDICAL AND PATHOLOGICAL INFORMATIONThe Office of the Chief State Medical Examiner, Newark, New Jersey, performed an autopsy of the pilot. The report listed the cause of death as blunt trauma. Toxicology testing was performed at the FAA Forensic Sciences Laboratory on specimens from the pilot. Acetaminophen, pseudoephedrine, and naproxen were detected in urine; pseudoephedrine was also detected in blood. Pseudoephedrine is a decongestant commonly marketed with the name Sudafed. Products containing this drug are only available "behind the counter" but do not require a prescription. Acetaminophen is an analgesic and fever reducer available over-the-counter and commonly marketed with the name Tylenol. Naproxen is an anti-inflammatory drug available over the counter and commonly marketed with the names Naprosyn and Aleve. These drugs are not considered impairing in usual doses.
An in-flight fire and total loss of engine power after takeoff due to a loose fuel line. Contributing to the accident was the installation of an unapproved fuel line by unknown personnel.
Source: NTSB Aviation Accident Database
Aviation Accidents App
In-Depth Access to Aviation Accident Reports
